Asbestos in construction
All types of asbestos can kill.
Asbestos was fully banned in the UK in 1999, but it remains the single greatest cause of work-related deaths in the UK. The time between exposure and disease varies widely. 20 tradespeople die each week from asbestos related diseases. Asbestos-related diseases include asbestosis, pleural thickening mesothelioma and asbestos-related lung cancer. Refurbishment, alteration and demolition projects are affected by asbestos in buildings. Material condition and type are key factors in the danger presented.
This article presents a brief overview of work with asbestos containing materials. Professional advice is essential in relation to asbestos.
You MUST have an appropriate survey and removal (if required) carried out by a competent surveyor or contractor. This process can take time and it is important that project programmes allow a realistic amount of time for this work and that budgets allow for realistic resources.
It is important that a full brief is provided for the survey in accordance with Asbestos: The survey guide HSG264. The surveyor must be made fully aware of work to be carried out and where access for construction is required. A survey may require access behind asbestos containing materials and therefore a contractor may be needed on site to open up the construction. Whilst sample analysis and report production take time and resources, a careful, proper, full survey will save time and cost on site and is a wise investment.
Asbestos is categorised as licensable or non-licensable in the UK (changes introduced by the new Control of Asbestos Regulations in April 2012 have now created a new category of notifiable non-licensable work). Contractors for licensable asbestos removal are held on a list by the Health and Safety Executive (HSE). Some asbestos-containing materials are non-licensable, such as asbestos cement panels and matrix-bound asbestos toilet cisterns. These may be removed by non-licence holders but the work must be carried out in accordance with HSE requirements by suitably trained personnel for the work (that is, personnel that have had training for work with non-notifies blue asbestos, not to be confused with asbestos awareness training).
All asbestos containing materials and asbestos contaminated waste must be disposed of to an Environment Agency licensed asbestos landfill site, carried by vehicles marked with hazardous waste signage.
Asbestos removal is covered by specific regulations with a strict 14-day notification period to the HSE before works can take place. If additional asbestos is found on site, unless there is strong case for a waiver (only granted for cases of imminent risk, for example, where the asbestos was not foreseeable and substantial financial loss would occur), method statements and notification periods are required by the HSE. A waiver is not taken lightly and the best approach is to ensure that a good quality survey is undertaken prior to the commencement of works on site.
The removal of asbestos is undertaken under very controlled conditions. There are exceptions, where asbestos is in a bound matrix (such as asbestos cement panels) and in a good condition (in accordance with proposed changes in the asbestos regulations for April 2012 where an additional class of notifiable non-licensable asbestos has been proposed created).
Asbestos removal is a specialised function. Proper decontamination facilities are needed for the workforce and a dedicated transit route must be provided to an enclosure kept under negative pressure. Airlocks need to be in place at the enclosure for air movement control and to permit those working to carry out preliminary decontamination procedures. Asbestos waste must be double bagged in labelled asbestos bags and properly stored in lockable skips on the transit route.
A rigorous, independent analyst inspection regime is in place providing a four stage clearance certification for removal of asbestos containing materials from site. This includes air monitoring within enclosures prior to dismantling the enclosure and visual inspection on completion of the work.
NB: The Control of Asbestos Regulations 2012 means that some non-licensed work must now be notified, written records kept, and by April 2015, workers must be under health surveillance by a doctor.
The following is a detailed list of components where the use of asbestos might be detected (ref. list published by Greenhalgh & Co, Chartered Surveyors):
- Acoustic plaster.
- Adhesives.
- Asbestos cement.
- Asphalt floor tiles.
- Base flashing.
- Blown-in Insulation.
- Boiler Insulation.
- Breaching Insulation.
- Caulking and putties.
- Ceiling tiles and lay-in panels.
- Cement pipes.
- Cement siding.
- Cement wallboard.
- Chalkboards.
- Construction mastics.
- Cooling towers.
- Decorative plaster.
- Ducting.
- Electric wiring insulation.
- Electrical cloth.
- Electrical panel partitions.
- Elevator brake shoes.
- Elevator equipment panels.
- Fire blankets.
- Fire curtains.
- Fire doors.
- Fireproofing materials.
- Flexible fabric connections.
- Flooring backing.
- Heating and electrical ducts.
- High temperature gaskets.
- HVAC duct insulation.
- Jointing compounds.
- Laboratory gloves.
- Laboratory hoods.
- Packing materials.
- Pipe insulation.
- Roofing felt.
- Roofing shingles.
- Spackling compounds.
- Spray-applied insulation.
- Table tops.
- Taping compounds.
- Textured paints and coatings.
- Thermal paper products.
- Vinyl floor tiles.
- Vinyl sheet flooring.
- Vinyl wall coverings.
- Wallboard.
The Control of Asbestos Regulations 2012 states:
“asbestos” means the following fibrous silicates— (a) asbestos actinolite, CAS No 77536-66-4; (b) asbestos grunerite (amosite), CAS No 12172-73-5; (c) asbestos anthophyllite, CAS No 77536-67-5; (d) chrysotile, CAS No 12001-29-5 or CAS No 132207-32-0; (e) crocidolite, CAS No 12001-28-4; and (f) asbestos tremolite, CAS No 77536-68-6, and reference to “CAS” followed by a numerical sequence are references to CAS Registry Numbers assigned to chemicals by the Chemical Abstracts Service, a division of the American Chemical Society; |
NB: On 30 September 2015, the Asbestos Removal Contractors Association (ARCA) published a free guidance note for clients appointing asbestos contractors.
In June 2018, it was announced that the US Environmental Protection Agency (EPA) was proposing allowing greater use of asbestos in construction materials. The US already allows the use of asbestos in products where it accounts for less than one percent. It is now considering a 'significant new use rule', evaluated on a case-by-case basis. President Trump had previously written; 'I believe that the movement against asbestos was led by the mob, because it was often mob-related companies that would do the asbestos removal.'
See also: Asbestos management.
[edit] Related articles on Designing Buildings
- Achieve safety in demolition.
- Asbestos cement.
- Asbestos coating.
- Asbestos insulation.
- Asbestos management.
- Asbestos register.
- Asbestos surveyor.
- Ceiling tiles.
- Construction dust.
- Contaminated land.
- Control of Asbestos Regulations 2012 CAR12.
- Deleterious materials.
- Failure to mention asbestos.
- Fire blanket.
- Five signs you are at risk of asbestos poisoning at work.
- Licensable work with asbestos.
- Silica.
- The risk of asbestos on brownfield sites.
[edit] External references
- Information from the Health and Safety Executive.
- Asbestos Removal Contractors Association.
- Control of Asbestos Regulations 2006.
- HSE, Asbestos: The Licensed Contractors Guide HSG247
- HSE, A comprehensive guide to managing asbestos in premises HSG227.
- HSE, Work with materials containing asbestos ACoP for the Control of Asbestos Regulations 2006 L143
- HSE, Asbestos: The survey guide HSG264
- Asbestos is the subject of the Health and Safety Executive’s Hidden Killer campaign.
- Department for Education Asbestos management in schools.
- The Control of Asbestos Regulations 2012.
Featured articles and news
The UK's Modern Industrial Strategy: A 10 year plan
Previous consultation criticism, current key elements and general support with some persisting reservations.
Building Safety Regulator reforms
New roles, new staff and a new fast track service pave the way for a single construction regulator.
Architectural Technologist CPDs and Communications
CIAT CPD… and how you can do it!
Cooling centres and cool spaces
Managing extreme heat in cities by directing the public to places for heat stress relief and water sources.
Winter gardens: A brief history and warm variations
Extending the season with glass in different forms and terms.
Restoring Great Yarmouth's Winter Gardens
Transforming one of the least sustainable constructions imaginable.
Construction Skills Mission Board launch sector drive
Newly formed government and industry collaboration set strategy for recruiting an additional 100,000 construction workers a year.
New Architects Code comes into effect in September 2025
ARB Architects Code of Conduct and Practice available with ongoing consultation regarding guidance.
Welsh Skills Body (Medr) launches ambitious plan
The new skills body brings together funding and regulation of tertiary education and research for the devolved nation.
Paul Gandy FCIOB announced as next CIOB President
Former Tilbury Douglas CEO takes helm.
UK Infrastructure: A 10 Year Strategy. In brief with reactions
With the National Infrastructure and Service Transformation Authority (NISTA).
Ebenezer Howard: inventor of the garden city. Book review.
The Grenfell Tower fire, eight years on
A time to pause and reflect as Dubai tower block fire reported just before anniversary.
Airtightness Topic Guide BSRIA TG 27/2025
Explaining the basics of airtightness, what it is, why it's important, when it's required and how it's carried out.
Construction contract awards hit lowest point of 2025
Plummeting for second consecutive month, intensifying concerns for housing and infrastructure goals.
Understanding Mental Health in the Built Environment 2025
Examining the state of mental health in construction, shedding light on levels of stress, anxiety and depression.
The benefits of engaging with insulation manufacturers
When considering ground floor constructions.
Lighting Industry endorses Blueprint for Electrification
The Lighting Industry Association fully supports the ECA Blueprint as a timely, urgent call to action.
Comments
To start a discussion about this article, click 'Add a comment' above and add your thoughts to this discussion page.